Notices. Notice of proposed rulemaking (NPRM)

1,722 words·~8 min read·/register/2012/01/19/2012-854

A research copy — for the controlling text, always check the official state or federal source. Not legal advice.

BILLING CODE 3510-22-P 77 12 Thursday, January 19, 2012 Proposed Rules DEPARTMENT OF TRANSPORTATION Federal Aviation Administration 14 CFR Part 39 [Docket No. FAA-2011-1418; Directorate Identifier 2011-NM-187-AD] RIN 2120-AA64 Airworthiness Directives; Bombardier, Inc. Airplanes AGENCY: Federal Aviation Administration (FAA), DOT. ACTION: Notice of proposed rulemaking (NPRM). SUMMARY: We propose to adopt a new airworthiness directive

(AD)for certain Bombardier, Inc. Model DHC-8-400 series airplanes. This proposed AD was prompted by chafing on high pressure fuel lines due to improper installation of an expandable pin on the lower cowl assembly. This proposed AD would require installing spring clips and repositioning the lanyard attachment points at the forward end and the forward firefloor of the lower cowl. We are proposing this AD to prevent chafing of the high pressure fuel lines, which if not corrected, could cause fuel leakage in a fire zone. DATES: We must receive comments on this proposed AD by March 5, 2012. ADDRESSES: You may send comments by any of the following methods: • *Federal eRulemaking Portal:* Go to *http://www.regulations.gov.* Follow the instructions for submitting comments. • *Fax:*

(202)493-2251. • *Mail:* U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590. • *Hand Delivery:* U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. For service information identified in this proposed AD, contact Bombardier, Inc., Q-Series Technical Help Desk, 123 Garratt Boulevard, Toronto, Ontario M3K 1Y5, Canada; telephone

(416)375-4000; fax

(416)375-4539; email *thd.qseries@aero.bombardier.com;* Internet *http://www.bombardier.com.* You may review copies of the referenced service information at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, Washington. For information on the availability of this material at the FAA, call

(425)227-1221. Examining the AD Docket You may examine the AD docket on the Internet at *http://www.regulations.gov;* or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone

(800)647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt. FOR FURTHER INFORMATION CONTACT: Mazdak Hobbi, Aerospace Engineer, Propulsion and Services Branch, ANE-173, FAA, New York Aircraft Certification Office, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone

(516)228-7330; fax

(516)794-5531. SUPPLEMENTARY INFORMATION: Comments Invited We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2011-1418; Directorate Identifier 2011-NM-187-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments. We will post all comments we receive, without change, to *http://www.regulations.gov,* including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD. Discussion Transport Canada Civil Aviation (TCCA), which is the aviation authority for Canada, has issued Canadian Airworthiness Directive CF-2011-21, dated July 12, 2011 (referred to after this as “the MCAI”), to correct an unsafe condition for the specified products. The MCAI states: During routine maintenance, an operator discovered evidence of chafing on a high pressure

(HP)fuel line. The source of chafing was related to the improper installation of an expandable pin on the lower cowl assembly, which caused the lanyard to foul against the HP fuel line. This condition, if not corrected, may cause fuel leakage in a fire zone. Bombardier has issued Service Bulletin

(SB)84-71-13 to introduce spring clips to positively retain and control the lanyards, regardless of the installation orientation of the expandable pin to rectify this problem. You may obtain further information by examining the MCAI in the AD docket. Relevant Service Information Bombardier has issued Service Bulletin 84-71-13, dated May 19, 2011. The actions described in this service information are intended to correct the unsafe condition identified in the MCAI. FAA's Determination and Requirements of This Proposed AD This product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to our bilateral agreement with the State of Design Authority, we have been notified of the unsafe condition described in the MCAI and service information referenced above. We are proposing this AD because we evaluated all pertinent information and determined an unsafe condition exists and is likely to exist or develop on other products of the same type design. Costs of Compliance Based on the service information, we estimate that this proposed AD would affect about 83 products of U.S. registry. We also estimate that it would take about 3 work-hours per product to comply with the basic requirements of this proposed AD. The average labor rate is $85 per work-hour. Required parts would cost about $19 per product. Where the service information lists required parts costs that are covered under warranty, we have assumed that there will be no charge for these parts. As we do not control warranty coverage for affected parties, some parties may incur costs higher than estimated here. Based on these figures, we estimate the cost of the proposed AD on U.S. operators to be $22,742, or $274 per product. Authority for This Rulemaking Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority. We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. Regulatory Findings We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. For the reasons discussed above, I certify this proposed regulation: 1. Is not a “significant regulatory action” under Executive Order 12866; 2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); 3. Will not affect intrastate aviation in Alaska; and 4. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket. List of Subjects in 14 CFR Part 39 Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. The Proposed Amendment Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows: PART 39—AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows: Authority: 49 U.S.C. 106(g), 40113, 44701. § 39.13 [Amended] 2. The FAA amends § 39.13 by adding the following new AD: **Bombardier, Inc.:** Docket No. FAA-2011-1418; Directorate Identifier 2011-NM-187-AD.

(a)Comments Due Date We must receive comments by March 5, 2012.

(b)Affected ADs None.

(c)Applicability This AD applies to Bombardier, Inc. Model DHC-8-400, -401, and -402 airplanes; certificated in any category; serial numbers 4001, 4003 through 4354 inclusive; and 4356 through 4363 inclusive.

(d)Subject Air Transport Association

(ATA)of America Code 71: Power Plant.

(e)Reason This AD was prompted by chafing on high pressure fuel lines due to improper installation of an expandable pin on the lower cowl assembly. We are issuing this AD to prevent chafing of the high pressure fuel lines, which if not corrected, could cause fuel leakage in a fire zone.

(f)Compliance You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.

(g)Actions Within 6,000 flight hours or 36 months after the effective date of this AD, whichever occurs first, install new or serviceable spring clips and re-position the lanyard attachment points, in accordance with the Accomplishment Instructions of Bombardier Service Bulletin 84-71-13, dated May 19, 2011.

(h)Other FAA AD Provisions The following provisions also apply to this AD:

(1)*Alternative Methods of Compliance (AMOCs):* The Manager, New York Aircraft Certification Office (ACO), ANE-170, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the ACO, send it to ATTN: Program Manager, Continuing Operational Safety, FAA, New York ACO, 1600 Stewart Avenue, Suite 410, Westbury, New York 11590; telephone

(516)228-7300; fax

(516)794-5531. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office. The AMOC approval letter must specifically reference this AD.

(2)*Airworthy Product:* For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered FAA-approved if they are approved by the State of Design Authority (or their delegated agent). You are required to assure the product is airworthy before it is returned to service.

(i)Related Information Refer to MCAI Canadian Airworthiness Directive CF-2011-21, dated July 12, 2011; and Bombardier Service Bulletin 84-71-13, dated May 19, 2011; for related information. Issued in Renton, Washington, on January 6, 2012. Ali Bahrami, Manager, Transport Airplane Directorate, Aircraft Certification Service. [FR Doc. 2012-854 Filed 1-18-12; 8:45 am]

Connectionstraces to 4

Traces to 4 documents

U.S. Code