Notices. Notice

1,441 words·~7 min read·/register/2004/04/21/04-8996

A research copy — for the controlling text, always check the official state or federal source. Not legal advice.

BILLING CODE 4160-01-S DEPARTMENT OF HEALTH AND HUMAN SERVICES Food and Drug Administration [Docket No. 2003N-0525] Agency Information Collection Activities; Submission for Office of Management and Budget Review; Comment Request; Hazard Analysis and Critical Control Point; Procedures for the Safe and Sanitary Processing and Importing of Juice AGENCY: Food and Drug Administration, HHS. ACTION: Notice. SUMMARY: The Food and Drug Administration

(FDA)is announcing that a proposed collection of information has been submitted to the Office of Management and Budget

(OMB)for review and clearance under the Paperwork Reduction Act of 1995. DATES: Fax written comments on the collection of information by May 21, 2004. ADDRESSES: OMB is still experiencing significant delays in the regular mail, including first class and express mail, and messenger deliveries are not being accepted. To ensure that comments on the information collection are received, OMB recommends that comments be faxed to the Office of Information and Regulatory Affairs, OMB, Attn: Fumie Yokota, Desk Officer for FDA, FAX: 202-395-6974. FOR FURTHER INFORMATION CONTACT: Peggy Robbins, Office of Management Programs (HFA-250), Food and Drug Administration, 5600 Fishers Lane, Rockville, MD 20857, 301-827-1223. SUPPLEMENTARY INFORMATION: In compliance with 44 U.S.C. 3507, FDA has submitted the following proposed collection of information to OMB for review and clearance. Hazard Analysis and Critical Control Point (HAACP); Procedures for the Safe and Sanitary Processing and Importing of Juice (OMB Control Number 0910-0466)—Extension These regulations mandate the application of HACCP procedures to fruit and vegetable juice processing. HACCP is a preventative system of hazard control that can be used by all food processors to ensure the safety of their products to consumers. A HACCP system of preventive controls is the most effective and efficient way to ensure that these food products are safe. FDA's mandate to ensure the safety of the nation's food supply is derived principally from the Federal Food, Drug, and Cosmetic Act (the act) (21 U.S.C. 321 *et seq.* ). Under the act, FDA has authority to ensure that all foods in interstate commerce, or that have been shipped in interstate commerce, are not contaminated or otherwise adulterated, are produced and held under sanitary conditions, and are not misbranded or deceptively packaged; under 21 U.S.C. 371, the act authorizes the agency to issue regulations for its efficient enforcement. The agency also has authority under the Public Health Service Act (42 U.S.C. 264) to issue and enforce regulations to prevent the introduction, transmission, or spread of communicable diseases from one State to another other State. Information development and recordkeeping are essential parts of any HACCP system. The information collection requirements are narrowly tailored to focus on the development of appropriate controls and document those aspects of processing that are critical to food safety. Through these regulations, FDA is implementing its authority under section 402(a)(4) of the act (21 U.S.C. 342(a)(4)). In the **Federal Register** of December 8, 2003 (68 FR 68400), FDA asked for public comment on the information collection. FDA received one comment. The comment stated that the agency had underestimated the annual recordkeeping burden of the regulation. The comment identified the following three sources of underestimated burden: 1. The comment stated that we underestimated the burden of validation required of importers in 21 CFR 120.14. We estimated the burden to be 4 hours, whereas the comment said that validation requires 30 to 40 hours per importer. 2. The comment stated that we underestimated the time required to document the monitoring of critical control points (21 CFR 120.8(b)(7)). We estimated 36 seconds; the comment said that 2 to 3 minutes is a better estimate. 3. The comment stated that we underestimated the number of times per week that processors verify records in accordance with 21 CFR 120.11. We estimated once per week but, according to the comment, many processors verify records more often. The comment said that some processors verify records daily. We have considered the three points raised in the comment. We will revise the estimated burden in response to the first point, but we find that the other two points do not require a revision of the estimated burden. The following are our detailed responses: 1. Part of the difference between our estimated burden under 21 CFR 120.14 and the estimate in the comment is that we computed burden per foreign source (308 entities) while the comment computes burden per importer (120 entities). Our burden per importer for validation is about 10 hours per year, which is still less than the comment's estimate but by a smaller order of magnitude. If foreign processors deal with multiple importers, the comment's estimate of 30 to 40 hours per importer is plausible. We therefore adjust the last line in the table in response to the comment. The hours per record change from 4 to 12 (column 5 of the table), and the total burden changes from 1,232 to 3,696 hours (column 6 of the table). This total burden corresponds to a burden of about 30 hours per importer. 2. The comment on documenting the monitoring of critical control points reflects some confusion about our calculation as presented in the burden table. Our estimate of 0.6 minutes per record is an average based on our overall estimate of the amount of additional recordkeeping time per hour required by the rule (on average an additional 3 minutes per hour). Some records will require more time to keep and others less. The comment may be correct that some records may take at least 2 to 3 minutes to make. However, the comment does not purport, and FDA does not believe, that all records will require that amount of time. Furthermore, many firms are already voluntarily performing a significant amount of the activities required to keep the records required by the rule to maintain good quality control to protect their brand value. Our estimate of the recordkeeping burden attributable to this rule is only for those additional activities that firms have not been doing prior to the rule, but undertake to comply with the rule. 3. The verification burden under 21 CFR 120.11 is based on the number of records that need to be verified. We say that each record must be verified within a week, so verification can be done weekly. But the burden is the same if verification is done twice a week or daily because the number of records to be verified is the same. So the burden would not change if we assumed more frequent verification. FDA estimates the burden of this collection of information as follows: **Table 1.—Estimated Annual Recordkeeping Burden** 1 21 CFR Sections No. of Recordkeepers Annual Frequency of Recordkeeping Total Annual Records Hours per Record Total Hours 120.6(c) and 120.12(a)(1) and

(b)1,875 365 684,375 0.1 68,438 120.7, 120.10(a), and 120.12(a)(2), (b), and

(b)1,450 14,600 21,170,000 0.01 211,700 120.10(c) and 120.12(a)(4)(ii) and

(b)1,840 12 22,080 0.1 2,208 120.11(a)(1)(iv), 120.11 (a)(2), and 120.12 (a)(5) 1,840 52 95,680 0.1 9,568 120.11(b) and 120.12(a)(5) and

(b)1,840 1 1,840 4 7,360 120.11(c) and 120.12(a)(5) and

(b)1,840 1 1,840 4 7,360 120.14(a)(2) and 120.14(c) and

(d)308 1 308 12 3,696 Total hours 360,930 1 There are no capital costs or operating and maintenance costs associated with this collection of information. Table 1 provides a breakdown of the total estimated annual recordkeeping burden. The estimates in this table have been reviewed by the agency's HACCP experts, who have practical experience in observing various processing operations and related recordkeeping activities. The burden estimates in table 1 are based on an estimate of the total number of juice manufacturing plants (i.e., 2,300) affected by the regulations. Included in this total are 850 plants currently identified in FDA's official establishment inventory plus 1,220 very small apple juice manufacturers and 230 very small orange juice manufacturers. The total burden hours are derived by estimating the number of plants affected by each portion of this final rule and multiplying the corresponding number by the number of records required annually and the hours needed to complete the record. These numbers were obtained from the agency's final regulatory impact analysis prepared for these regulations. Moreover, these estimates assume that every processor will prepare sanitary standard operating procedures and a HACCP plan and maintain the associated monitoring records and that every importer will require product safety specifications. In fact, there are likely to be some small number of juice processors that, based upon their hazard analysis, determine that they are not required to have a HACCP plan under these regulations. Dated: April 15, 2004. Jeffrey Shuren, Assistant Commissioner for Policy. [FR Doc. 04-8996 Filed 4-20-04; 8:45 am]

Connectionstraces to 8

Traces to 8 documents

U.S. Code

CFR

Citation graph

cites case law

Notices

Notice